Was finally able to install
First 2 pictures show starting pond and holding tank 400’ away 120’ elevation next photo is float put together this winter to set pump on next shows pump set up next is completed project one day to put up panels and float takes 50 lbs to push water to tank
I have one of these pumps. I was skeptical that it would work, but I am amazed how well it does. I do believe I will be adding some more solar panels. This is the bigger of my two ponds. I will be ordering one for my smaller pond.
My previous solar pump bit the dust this spring and I needed an urgent replacement to provide water for 40 bison and myself. The kit arrived in time and the instructions were very good. Can't quite describe the feeling I had when the water started flowing again. So far so good.
We have completed the installation of solar components and have water!
Here are a few photos and highlights of what we did and our ideas that helped or could be emphasized more.
The order came quickly within days and was complete. No faulty pieces.
The book was read and reread, and also we watched various youtube videos which was such a plus!
The great emphasis and encouragement to write down what wire matched up with the pump 1,2 and 3 was perfect. Memory can fade when interruption or time passes between different steps.
We would have liked a shorter attachment pipe between the pitless and check valve we added to our above ground system and was also how we attached the check valve to the pump at bottom of well.
The clamps seemed to be a bit long for 3/4" and we just wrapped extra black electrician tape to secure those clamp ends from catching our wires etc.
It is a 2 person job to get this done and I don’t know how a lone person would do all the steps and heavy lifting etc. Encourage people to acquire a helper just to be extra hands and support.
By the time we lowered well pump, and installed solar and pipe above ground a whole week had passed (2 days
to install technically or 3 days counting pitless install). We may not have had perfect sun on the panels but measured flow at 1.67 gallons a minute. We dropped pump at 100' (from top of well, 95 from pitless) The water was clear to the eye but we see in the tank it is cloudy dirty so we have further pumping to get it clear. No official tests yet just getting the water to flow was late afternoon.
We are pretty happy to see water from our drilled well, elated to be on this side of the well project.
I have set it up temporarily since ground is too hard to dig a ditch by hand right now. It’s a small unlined pond still in the works.....but water is getting a little clearer despite the clay churning. And it seems cleaner and doesn't smell. Thanks!
